NM6-135 Diesel Engines for Fire Pump Drivers

NM6-135 Diesel Engines for Fire Pump Drivers

Pump Data Sheets:

Characteristics

It is a kind of engine in accordance with fire fighting standard. Compared with normal engine, it is more stable

and reliable. Its design concept is to protect the security of human and their property, but normal engine considers

more about its performance.

1. starting system: there are three kinds of starting types of fire fighting engine: main controller starting,

instrumentation starting and emergency starting. And from the crank speed within 20s, to the rated speed and

rated power.

Main controller starting: controller can result in the pressure of pipe net goes down then automatically starting ,

and press 'manual' buttom to start.

Instrumentation starting: Press 'manual’ buttom of the instrumention to start.

Emergency starting: if the main controller and instrumention all broken down , emergency manual starting can start

the fire engine.

2. Battery: fire fighting engine usually equiped with two sets of batteries for power supply. To ensure the battery full

of power and can quick start the fire fighting engine at any time, here are two kinds of charging ways: connecting to

AC power or using generator of the engine for charging.

Battery capacity: At 40℉ (4℃), each battery shall have twice the capacity sufficient to maintain 3-minute

attempt-to-start cycle, which is six consecutive cycles of 15 seconds of cranking and 15 seconds of rest.

Batteries based on calculations, to have capacity for 72 hours of standby power without ac power being

available for battery charging.

3. Jacket water heater: fire fighting engine equipped with jacket water heater to heat the coolant and keep

49℃ of the cylinder,to ensure the engine can quick start at any time.

4. Cooling system: fire fighting engine equipped with water pump , as the pump end is full of water and

water cooling has good effect, cooling type of diesel engine normally choose water cooling.

5. Exhaust system: fire fighting engine need equipped with seperate exhaust system ,and connect flexible

joint on the exhaust vent, to absorb the heat and cut off the engine vibration .

6. Fuel supply &return system: fire fighting engine must equipped with an independent fuel supply &return

system, The fuel tank is sized for 5.07 liter/kW (1gal/HP) plus 10% (5% for expansion and 5% forsump),for

make sure enough fuel.

7. Coupling:Engines shall be connected to horizontal shaft pumps by means of a flexible coupling.The flexible

coupling shall be directly attached to the engine flywheel adapter.

8. Alarm signal: when fire fighting diesel engine at low oil pressure,high coolant temperature, low coolant

temperature, over speed, high cooling raw water , they will send out alarm signal, but all this alarm signal will

not fire fighting diesel engine , except over speed .

Wuhan Spico Machinery & Electronics Co., Ltd.（Hereinafter referred to as SPICO） is the Wuhan

office of  CNP NM Fire-fighting System Co.,Ltd (Hereinafter referred to as NM Fire). SPICO mainly resp-

onsible for product promotion，export declaration and foreign exchange collection of overseas orders.NM

Fire  is the subsidiary of Nanfang Zhongjin Environment Co.,Ltd, which islocated in Hunan Changsha

Economic and Technological Development Zone, mainly produceand sell Diesel engine &Motor fire pump

groups ,controllers and fire pumps which are in accordance with domestic & international standards and have

gotten related certifications .

With the help of multi-national engineers with more than 20 years of professional experience, the NMFIRE

technical team fully understands the technical requirements of fire fighting systems. They have overcome

difficulties, conquered technical aspects, created China's first in this industry and opened up a new market

for China's fire fighting research andtechnology.

The company’s mission is to protect the community fire safety, in line with the spirits of “integrity,

win-win”,glad to provide high cost-effective products and high-quality service for our customers.

Fire fighting is the last protection for life and property. These include strict technical, quality and testing requirements

for fire fighting equipment that are specified in the UL/FM product standard.

Under the premise of fully learning and understanding these standards, our company has invested huge sums of money

and energy in research and development of new products. Many innovative technologies have been developed through

product R&D. The pumps and diesel engines have reached the level of first class in the world. The research and

development of these two critical products has put an end to the long history in the domestic marketplace of taking

non-certified ordinary water pumps and diesel engines and using them in life safety applications. This has also completely

changed the domestic technology level of this industry and has allowed NM FIRE to lead the market

Start by meeting the customer obvious needs, follow by continuously deepening and exploring potential customer demand,

meanwhile, plant the philosophy into our soul.